Product ID:V-740 VISILOX
MSDS Date:10/26/1996
FSC:6850
NIIN:00-927-9461
Status Code:A
MSDS Number: CJFYF

Emergency Phone: 800-356-7560

Info Phone: 609-860-4000/800-356-7560

Cage: LO755

Telephone: 215-743-8200

Cage: 2B613

ZINC OXIDE (ZNO)

CAS: 1314-13-2

RTECS: ZH4810000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

DIMETHYLPOLYSILOXANE FLUID

CAS: 63148-62-9

RTECS: JT6484500

LD50 LC50 Mixture:LD50 (ORAL, MOUSE) 7,950 MG/KG
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN (HMIS).
ACUTE - EYE: SLIGHTLY IRRITATING. MAY CAUSE REDNESS, IRRITATION.
SKIN: SLIGHTLY IRRITATING. MAY CAUSE REDNESS, IRRITATION.
INHALATION. INHALATION IS NOT AN EXPECTED R OUTE OF EXPOSURE.
INGESTION: PRACTICALLY NON-TOXIC. CHRONIC EFFECTS - THIS PRODUCT
DOES NOT CONTAIN ANY INGREDIENT DESIGNATED BY IARC, NTP, ACGIH OR
OSHA AS PROBABLE OR SUSPECTED HUMAN CARCINOGENS.
Explanation of Carcinogenicity:CONTAINS DIMETHYLPOLYSILOXANE WHICH CAN
GENERATE FORMALDEHYDE AS A BYPRODUCT OF OXIDATIVE THERMAL
DECOMPOSITION BEGINNING AT APPROXIMATELY 150C (300F). FORMALDEHYDE
IS LISTED AS A POTENTIAL HUMAN CARC INOGEN BY IARC, NTP, OSHA AND
ACGIH.
Effects of Overexposure:REDNESS, IRRITATION, TEARING

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION: INHALATION
IS NOT AN EXPECTED ROUTE OF EXPOSURE. IF RESPIRATORY IRRITATION OR
DISTRESS OCCURS, REMOVE VICTIM TO FRESH AIR. EYE EXPOSURE:
IMMEDIATELY A BSORB EXCESS WITH CLEAN ABSORBENT CLOTH OR COTTON.
THEN, HOLD EYELIDS OPEN AND FLUSH WITH A STEADY, GENTLE STREAM OF
WATER FOR AT LEAST 15 MINUTES. SKIN EXPOSURE: WIPE EXCESS OFF SKIN
WITH A DRY CLOT H; THEN WASH SKIN WITH PLENTY OF SOAP AND WATER.
INGESTION: IF CONSCIOUS AND ALERT, DRINK 1-2 GLASSES OF WATER. GET
MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. DO NOT LEA VE VICTIM UNATTENDED.

Flash Point Method:COC
Flash Point:>260.C, 500.F
WILL BURN
Lower Limits:NO DATA
Upper Limits:NO DATA
Extinguishing Media:DRY CHEMICAL. FOAM, CARBON DIOXIDE
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR NIOSH/MSHA APPROVED
SELF CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING.
COOL CONTAINERS EXPOSED TO FIRE WITH WATER.
Unusual Fire/Explosion Hazard:PRODUCT WILL BURN UNDER FIRE CONDITIONS.

Spill Release Procedures:CAUTION: SPILLED MATERIAL MAY MAKE THE FLOOR
SLIPPERY. ABSORB SPILL WITH AN INERT ABSORBENT. SCRAPE UP AND PLACE
IN APPROPRIATE CLOSED CONTAINER FOR RECLAMATION OR DISPOSAL. CLEAN
UP RESIDUAL MATERIAL WITH AN APPROPRIATE SOLVENT SUCH AS PAINT
THINNER OR MINERAL SPIRIT, PROVIDED THAT THERE IS GOOD VENTILATION
AND NO IGNITION SOURCES. DO NOT FLUSH TO DRAIN.

Handling and Storage Precautions:STORE IN A CLEAN, DRY, WELL-VENTILATED
AREA AWAY FROM IGNITION SOURCES, AND INCOMPATIBLE MATERIALS. KEEP
CONTAINER TIGHTLY CLOSED. STORE BETWEEN 4 TO 38C (39 TO 100F).
Other Precautions:AVOID BREATHING VAPORS AND MISTS. AVOID DIRECT OR
PROLONGED CONTACT WITH EYES AND SKIN. WASH THOROUGHLY AFTER
HANDLING AND BEFORE EATING OR DRINKING. REMOVE CONTAMINATED
CLOTHING PROMPTLY. LAUNDER BEF ORE REUSE. KEEP OUT OF REACH OF
CHILDREN.

Respiratory Protection:SELECT NIOSH/MSHA APPROVED EQUIPMENT BASED ON
ACTUAL OR POTENTIAL AIRBORNE CONCENTRATIONS AND IN ACCORFANCE WITH
APPROPRIATE REGULATORY STANDARDS AND/OR INDUSTRIAL RECOMMENDATIONS.
FOR REASONABLY FORE SEEABLE INDUSTRIAL END USES OT THE MATERIAL,
RESPIRATORY PROTECTION SHOULD NOT BE NECESSARY.
Ventilation:TO MINIMIZE EMPLOYEE EXPOSURES: GENERAL AREA
DILUTION/EXHAUST VENTILLATION.
Protective Gloves:GLOVES DURABLE AS WELL AS PERMEATION RESISTANCE
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS
Other Protective Equipment:LONG SLEEVEDCLOTHING (SHIRTS AND PANTS). EYE
BATH, WASHING FACILITY
Work Hygienic Practices:DO NOT STORE, USE, CONSUME FOOD, DRINK, TOBACCO
PRODS, COSMETICS IN AREA WHERE MATERIAL IS STORED. WASH HANDS AND
FACE BEFORE EAT, DRINK, USE TOBACCO/COSMETICS OR USE TOILET. WASH
EXPOED SKIN PROMPTLY.
Supplemental Safety and Health

HCC:V5
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Vapor Pres:NOT AVAILABLE
Spec Gravity:2.43@25C(77F)
Solubility in Water:INSOLUBLE
Appearance and Odor:ODORLESS, WHITE PASTE-LIKE SOLID

Stability Indicator/Materials to Avoid:YES
STRONG BASES, SRONG ACIDS, STRONG OXIDIZING AGENTS, COMBUSTIBLE
MATERIALS
Stability Condition to Avoid:HEAT, OPEN FLAME, SPARK
Hazardous Decomposition Products:DIMETHYLCYCLOSILOXANES;
METHYLPHENYLCYCLOSILOXANES, FORMALDEHYDE

Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS. EPA HAZARDOUS WASTE: NO.
ANY CONTAINER OR EQUIPMENT USED SHOULD BE DECONTAMINATED
IMMEDIATELY AFTER USE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA FOUND.

SARA Title III Information:NONE
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE ON
THE TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY LIST.
State Regulatory Information:THIS PRODUCT DOES NOT CONTAIN ANY
COMPONENTS THAT ARE REGULATED UNDER THE STATE OF CALIFORNIA
PROPOSITION 65.